If all else fails- Ethanol in the gas makes the needle valve stick. Its because the needle valve has a rubber tip and the alcohol in the gas...
I also have a 1966 CJ6
Interesting CJ6. I have a 1966 Cj6 that I put a 231 odd-fire into. It is lifted 5 inches, has 11 in brakes, Power Sig Steering, Dana 30 front,...
This looked like a chewing gum wrapper, but an additive bottle seal could to the same thing. I took the tank out-- and the sensor top off,...
Tnanks-- Yes of course I have a filter between the gas tank and the fuel pump to keep junk from hurting my electric fuel pump. Originally in...
I have my 1966 with an under the seat gas tank. It is old and been repaired-- the original outlet walled off, and the drain hole fitted with an...
I converted to a Carter 4070 Electric pump and removed the machanical pump. Even a new machanical pump started to go bad in one month. This is...
excellent repair job on the piviot for the e-brake. On my D-18 the piviot bolt was a little loose, so I knerled the bolt and repressed it in...
If you cannot find manifolds-- make a set of short headers using the flanges to your existing old headers. Cut the Header pipes off ----Have...
There are about 5 or 6 different thicknesses or lengths of throw-out bearing. If you got one that is too short, the bearing will not contact the...
Exactly right-- I trimed mine and built an arch out of heavy sheet metal and bolted the new sheet metal arch to reinforce were I did the...
I put a Buick V6 in my 1966 CJ6 with Hedman Headers. I mounted the engine to the Driver's side 2 inches over from center. That way I got more...
Yea my 66 CJ6 was some kind of Forest Service or AGGIE Jeep. It was painted that Forest Service Green, with a gray windshield frame---the tail...
Yea-- I even noticed how my rubber fuel hoses get rock hard, and how the paper element in my clear gas filter turns very dark colored right a...
My Cj6 (Dauntless powered) was running A-OK for a number of months on a new Rochester 2G. But one afternoon it just died in traffic and would...
You might pull the spark plugs out and soak the pistons (and Rings) in WD-40 for a fews days. This is on the outside chance that the rings could...
That looks like a nice CJ6. Mine came with a 4 cyl-- so I put in a Buick V6 I would guess it is worth about 6000 dollars
Often Brake drums have to be pulled off of the hub. But I have some with a special problem. These are a Dana 27 8" drums on the front full...
I would recommend that you get a AC Delco Alt. It simplifies your charging system with an internal regulator.
Running only a rear bar is initially done to keep the whole weight of the vehicle from crushing the drive and passengers. A front bar proved...
Separate names with a comma.