1. Registration trouble? Please use the "Contact Us" link at the bottom right corner of the page and your issue will be resolved.
    Dismiss Notice

Offenhauser Intake Heater Hose?

Discussion in 'Early CJ5 and CJ6 Tech' started by Strider380, May 11, 2019.

  1. Strider380

    Strider380 Can I have a zip tie?

    Hello I have a new to me dauntless V6 with Offenhauser 360 intake. I am trying to hook up the cooling system but I have no idea where the old owner put the heater hose. My old hookup was on the rear of the stock intake. This intake has no ports except one in the front that is plugged off. Its slightly behind the thermostat housing and im sure connects to it. I assume it probably goes there but doesn’t seem right to me. I have researched the Offenhauser catalogs to no avail. Lots of offenhauser 360 intakes have ports all over but this only has that one single port. Any help would be much appreciated!!!
     
    Last edited: May 11, 2019
  2. Rich M.

    Rich M. Shoe salesman 2024 Sponsor 2023 Sponsor 2022 Sponsor

    IMG_20190511_172411566~3.jpg IMG_20190511_172255642_LL~4.jpg
    You'll have to t in your temp sender or get otherwise creative. The later versions have multiple ports.
     
  3. Lee Bennett

    Lee Bennett Banned

    I have that same intake. Rich M is correct. The outlet below the words dual port have my heater hose. Facing the front are 2. One for the temp sensor and the other for the thermostat bypass. Sounds like your plugged off one is for your heater hose. You do have to remove the coil to install / replace the temp sensor. I have a pic but it's too big to upload.
     
  4. Rich M.

    Rich M. Shoe salesman 2024 Sponsor 2023 Sponsor 2022 Sponsor

    They loaded in reverse order. The top is a 360 equaflow while the bottom is a 360 dualport with no other water port options.
     
  5. Lee Bennett

    Lee Bennett Banned

    Mine is the dual port also
     
  6. Strider380

    Strider380 Can I have a zip tie?

    Thanks a lot everyone!
     
    Focker likes this.