1. Registration trouble? Please use the "Contact Us" link at the bottom right corner of the page and your issue will be resolved.
    Dismiss Notice

Fixed: V6 Cutting out at cruising speeds?

Discussion in 'Early CJ5 and CJ6 Tech' started by sparky, May 14, 2006.

Page 18 of 50
  1. Jul 28, 2006
    sparky

    sparky Sandgroper Staff Member Founder

    Perth, WA
    Joined:
    Sep 20, 2002
    Messages:
    9,221
    Re: V6 Cutting out at cruising speeds?

    It did it with both points and HEI. No change in behavior at all. I don't think switching yet again will help much.

    I think I can rule the gas tank thing out. Look above.
     
    sparky, Jul 28, 2006
    #341
  2. Jul 28, 2006
    blevisay

    blevisay Oh Noooooooooooooooo! Staff Member

    Portland Tn.
    Joined:
    Sep 20, 2002
    Messages:
    4,350
    Re: V6 Cutting out at cruising speeds?



    Ok I am going waay out on a limb here, but I have seen it happen once.


    Disconnect the tach.......I had one short on me once.


    Then send me a case of beer
     
    blevisay, Jul 28, 2006
    #342
  3. Jul 28, 2006
    jpflat2a

    jpflat2a what's that noise?

    Hermosa, SD
    Joined:
    Jul 30, 2003
    Messages:
    8,523
    Re: V6 Cutting out at cruising speeds?

    spark plugs
    buy what you like and drink it for me !
     
    jpflat2a, Jul 28, 2006
    #343
  4. Jul 28, 2006
    MCSCOTT

    MCSCOTT Member

    Columbia, Tn
    Joined:
    Apr 24, 2006
    Messages:
    905
    Re: V6 Cutting out at cruising speeds?

    Oooooooo, I have seen this before too when it was a bad connection with a tach on one. When the tach would quit working, the engine would run perfect, when it was working, it would fall on it's face. Another vote for disconnecting it just to check.
     
    MCSCOTT, Jul 28, 2006
    #344
  5. Jul 28, 2006
    Mudweiserjeep

    Mudweiserjeep JEEP: Bouncy and Fun

    tipp city, ohio
    Joined:
    Jun 17, 2004
    Messages:
    718
    Re: V6 Cutting out at cruising speeds?

    muffler bearings?.................R) sorry I couldn't resist.
     
    Mudweiserjeep, Jul 28, 2006
    #345
  6. Jul 28, 2006
    sparky

    sparky Sandgroper Staff Member Founder

    Perth, WA
    Joined:
    Sep 20, 2002
    Messages:
    9,221
    Re: V6 Cutting out at cruising speeds?

    I replaced those and the knuter valve between the header collector and muffler while I had the headers off Tim.
     
    sparky, Jul 28, 2006
    #346
  7. Jul 28, 2006
    MCSCOTT

    MCSCOTT Member

    Columbia, Tn
    Joined:
    Apr 24, 2006
    Messages:
    905
    Re: V6 Cutting out at cruising speeds?

    From reading through most of this again, I have come to the conclusion at there is nothing wrong with your Jeep, it has to just be your imagination.:) :)
     
    MCSCOTT, Jul 28, 2006
    #347
  8. Jul 28, 2006
    sparky

    sparky Sandgroper Staff Member Founder

    Perth, WA
    Joined:
    Sep 20, 2002
    Messages:
    9,221
    Re: V6 Cutting out at cruising speeds?

    I always did have a vivid imagination.

    Maybe it just wants new tires? R)
     
    sparky, Jul 28, 2006
    #348
  9. Jul 28, 2006
    Mudweiserjeep

    Mudweiserjeep JEEP: Bouncy and Fun

    tipp city, ohio
    Joined:
    Jun 17, 2004
    Messages:
    718
    Re: V6 Cutting out at cruising speeds?

    That's it!R) R)
     
    Mudweiserjeep, Jul 28, 2006
    #349
  10. Jul 28, 2006
    MCSCOTT

    MCSCOTT Member

    Columbia, Tn
    Joined:
    Apr 24, 2006
    Messages:
    905
    Re: V6 Cutting out at cruising speeds?

    R) Yep, if your Jeep is a spoiled brat, new tires might do the trick.
     
    MCSCOTT, Jul 28, 2006
    #350
  11. Jul 28, 2006
    jd7

    jd7 Sponsor

    Nacogdoches,Texas
    Joined:
    Mar 30, 2004
    Messages:
    1,745
    Re: V6 Cutting out at cruising speeds?

    mine always seemed to run like new with new tires;)
     
    jd7, Jul 28, 2006
    #351
  12. Jul 28, 2006
    mb82

    mb82 I feel great!

    Charlottesville Va
    Joined:
    Mar 17, 2003
    Messages:
    2,706
    Re: V6 Cutting out at cruising speeds?

    Sparky Chia is fighting me less since I got the new tires. So that might help.
     
    mb82, Jul 28, 2006
    #352
  13. Jul 28, 2006
    beeser

    beeser Member

    Arizona
    Joined:
    Jan 8, 2003
    Messages:
    587
    Re: V6 Cutting out at cruising speeds?

    No offense Sparky but how about taking up a collection to send jpflat2a (Jim) out there?
     
    beeser, Jul 28, 2006
    #353
  14. Jul 28, 2006
    vanguard

    vanguard

    Re: V6 Cutting out at cruising speeds?

    So you get up, hop in the Jeep (cold engine) start out, every things runs fine, even in 3rd gear and go about 2 miles (hot engine). Now we have backfiring problems - coughing. Does the carb have a choke pull-off? IIRC, its a 2G? Are the warm air passages from the intake open or closed?

    Coil could be failing as it gets hot? Let's change the spark plugs anyway, might have been damaged by backfiring or defective from the factory.
     
    vanguard, Jul 28, 2006
    #354
  15. Jul 28, 2006
    BlueFlu

    BlueFlu past owner of some ecj5's

    Hermitage, TN
    Joined:
    Jan 21, 2004
    Messages:
    1,552
    Re: V6 Cutting out at cruising speeds?

    The problem is the Jeep wants to come to Tellico. It knows if it runs bad long enough then fixes itself you might just bring it. R)

    Didn't think about the tach causing problems. Kind of a stretch but what do have to lose at this point.
     
    BlueFlu, Jul 28, 2006
    #355
  16. Jul 28, 2006
    spoon

    spoon New Member

    Spade, TX
    Joined:
    May 22, 2006
    Messages:
    8
    Re: V6 Cutting out at cruising speeds?

    Dang Sparky, Your jeep seemed to run good till i showed up. :oops:
     
    spoon, Jul 28, 2006
    #356
  17. Jul 28, 2006
    MOP

    MOP Active Member

    Pullman, WA
    Joined:
    Sep 25, 2003
    Messages:
    1,131
    Re: V6 Cutting out at cruising speeds?

    :cry: :cry:

    I can head over tonight and hand you a wrench or two if you want me to. IIRC, you ran the jeep with a gas can in the cab, bypassing the tank?
     
    MOP, Jul 28, 2006
    #357
  18. Jul 28, 2006
    sparky

    sparky Sandgroper Staff Member Founder

    Perth, WA
    Joined:
    Sep 20, 2002
    Messages:
    9,221
    Re: V6 Cutting out at cruising speeds?

    No, today was the first day it ran fine then acted up. Previously it'd act up immediately when I got to 55 mph.

    Choke is open, it's manual.

    Warm air passages were carboned shut prior to hot tanking. Blocked off by the gasket I'm currently using. So that's not changed, they're blocked.

    Coil(S) both 12V and HEI have exhibited the same symptom.
     
    sparky, Jul 28, 2006
    #358
  19. Jul 28, 2006
    jayhawkclint

    jayhawkclint ΜΟΛΩΝ ΛΑΒΕ

    Oklahoma City, USA
    Joined:
    May 18, 2006
    Messages:
    2,622
    Re: V6 Cutting out at cruising speeds?

    I have a recently rebuilt/working 2G on my Chevelle that I could send over if you want to try a different carb altogether. Came off a '70 GMC 307, so it probably is jetted a little richer. Car is just sitting for welding, so it wouldn't bother me any. Then I could just pick it up from you when you take Linus wheeling Labor Day;)
     
    jayhawkclint, Jul 28, 2006
    #359
  20. Jul 28, 2006
    sparky

    sparky Sandgroper Staff Member Founder

    Perth, WA
    Joined:
    Sep 20, 2002
    Messages:
    9,221
    Re: V6 Cutting out at cruising speeds?

    I appreciate the offer. I did already try another carb. Just ran worse but did the same thing. R)
     
    sparky, Jul 28, 2006
    #360
Page 18 of 50
New Posts